Research on Mixture Proportion Design and Mechanical Properties of Ceramsite Concrete
李腾飞 LI Teng-fei；张丽娟 ZHANG Li-juan；
阮铂淮 RUAN Bo-huai；朱怀 ZHU Huai；王志 WANG Zhi
（郑州大学力学与安全工程学院，郑州 450001）
（School of Mechanics and Safety Engineering，Zhengzhou University，Zhengzhou 450001，China）
摘要： 陶粒混凝土轻质多孔，具有较好的保温隔热性能，是制作外墙的理想材料。但是由于陶粒吸水率大、强度低，陶粒混凝土制备过程中易出现骨料上浮、工作性能差、强度低等问题。本文使用陶粒，陶砂为粗细骨料，水胶比选为0.40，0.45，0.50，制备3组不同配合比的陶粒混凝土，测定其的体积密度，3天和28天龄期的抗压强度、劈裂抗拉强度。最终制备出体积密度为1393kg/m3，抗压强度28.91MPa 、劈拉强度4.07MPa的轻质陶粒混凝土。
Abstract: Because of its light weight and porosity, ceramsite concrete has good thermal insulation performance, it is a suitable material for out wall material. However, due to the high water absorption rate and low strength of ceramsite, the aggregate floating, poor workability are easy to occur in the preparation process of ceramsite concrete. Ceramsite is used as coarse aggregate and ceramsite sand is used as fine aggregate, water-binder ratio is 0.40, 0.45, 0.50, three groups ceramsite concrete were prepared. 3d and 28d compressive strength and splitting tensile strength, and weight of ceramsite concrete were tested. Finally, the light ceramiste concrete with density of 1393kg/m3, compressive strength of 28.91MPa and tensile strength of 4.07MPa was produced.
关键词： 陶粒混凝土；配合比设计；抗压强度；劈拉强度
Key words: ceramsite concrete；mix proportion design；compressive strength；splitting tensile strength
中图分类号：TU528.2 文献标识码：A 文章编号：1006-4311（2022）19-157-03
DOI:10.3969/j.issn.1006-4311.2022.19.049.
文章出处：李腾飞,张丽娟,阮铂淮,等. 陶粒混凝土的配合比设计及力学性能研究[J]. 价值工程,2022,41(19):157-159.
|
